Remove disk from one filer and install it another

[ShahbazRiaz]

My English is not good, please try to understand

I have two Storages with 7-mode, one storage is online and 2nd is not in production/free. One drive found faulty in online storage. So we removed disk from free storage with "disk fail -i" command then installed it in online storage and found on error that the "fail disk detect".  The disk is only shown in GUI "broken" and when use command line the disk is not found anywhere.

Please help to resolve this issue.

[amans]

Hi,

Are you trying to tell that faulty disk has been replaced, but in GUI it says still broken and in CLI you do not see the failure?

Did you run sysconfig -a to see if the disk is marked as broken?

Regards,

Aman

[ShahbazRiaz]

ho-st02b> sysconfig -a

        NetApp Release 8.2.1 7-Mode: Fri Mar 21 14:48:58 PDT 2014

        System ID: 1926359701 (ho-st02b); partner ID: 1926363360 (ho-st02a)

        System Serial Number: 701414000808 (ho-st02b)

        System Rev: D6

        System Storage Configuration: Multi-Path HA

        System ACP Connectivity: Full Connectivity

        slot 0: System Board 1.7 GHz (System Board XIX D6)

                Model Name:         FAS2240-4

                Part Number:        111-00846

                Revision:           D6

sysconfig -r and sysconfig -a output  

              Serial Number:      9442552469

                BIOS version:       8.2.0

                Loader version:     4.2

                Processors:         4

                Processor ID:       0x106e4

                Microcode Version:  0xffff0002

                Processor type:     Intel(R) Xeon(R) CPU           C3528  @ 1.73GHz

                Memory Size:        6144 MB

                Memory Attributes:  Hoisting

                                    Normal ECC

                NVMEM Size:         768 MB of Main Memory Used

                CMOS RAM Status:    OK

                Controller:         B

        Service Processor           Status: Online

                Firmware Version:   2.2.1

                Mgmt MAC Address:   00:A0:98:57:20:08

                Ethernet Link:      up, 100Mb, full duplex, auto-neg complete

                Using DHCP:         no

        IPv4 configuration:

                IP Address:         10.0.9.86

                Netmask:            255.255.0.0

                Gateway:            10.0.9.2

        IPv6 configuration:         Disabled

        slot 0: Internal 10/100 Ethernet Controller

                e0M MAC Address:    00:a0:98:57:20:07 (auto-100tx-fd-up)

                e0P MAC Address:    00:a0:98:57:20:06 (auto-100tx-fd-up)

                Device Type:        Rev 0

                        memory mapped I/O base 0x00000000dfb20000, size 0x20000

                        I/O base 0x0000000000003000, size 0x20

                        memory mapped I/O base 0x00000000dfb00000, size 0x4000

                        memory mapped I/O base 0x00000000dfc00000, size 0x20000

                        I/O base 0x0000000000004000, size 0x20

                        memory mapped I/O base 0x00000000dfc20000, size 0x4000

        slot 0: Quad Gigabit Ethernet Controller 82580

                e0a MAC Address:    00:a0:98:57:20:02 (auto-unknown-down)

                e0b MAC Address:    00:a0:98:57:20:03 (auto-unknown-down)

                e0c MAC Address:    00:a0:98:57:20:04 (auto-unknown-down)

                e0d MAC Address:    00:a0:98:57:20:05 (auto-unknown-down)

                Device Type:    150E

                Firmware Version:   3.22, 0x80000101

                        memory mapped I/O base 0x00000000df900000, size 0x80000

                        I/O base 0x0000000000002040, size 0x20

                        memory mapped I/O base 0x00000000dfa08000, size 0x4000

                        memory mapped I/O base 0x00000000df980000, size 0x80000

                        I/O base 0x0000000000002060, size 0x20

                        memory mapped I/O base 0x00000000dfa0c000, size 0x4000

                        memory mapped I/O base 0x00000000df800000, size 0x80000

                        I/O base 0x0000000000002000, size 0x20

                        memory mapped I/O base 0x00000000dfa00000, size 0x4000

                        memory mapped I/O base 0x00000000df880000, size 0x80000

                        I/O base 0x0000000000002020, size 0x20

                        memory mapped I/O base 0x00000000dfa04000, size 0x4000

        slot 0: Interconnect HBA:   Mellanox IB MT25204

                GUID: 0x100000a098572002        LID: 0x5        Remote LID: 0x4

                Firmware rev:           1.0.800

                Hardware rev:           160

                Command rev:            1

                Interconnect Port: 4x

                        memory mapped I/O base 0xdf400000, size 0x100000

                        prefetchable memory base 0xde800000, size 0x800000

        slot 0: SAS Host Adapter 0a (PMC-Sierra PM8001 rev. C, SAS, <UP>)

                Firmware rev:       01.11.07.00

                Base WWN:           5:00a098:0035b51:30

                Phy State:          [0] Enabled, 6.0 Gb/s

                                    [1] Enabled, 6.0 Gb/s

                                    [2] Enabled, 6.0 Gb/s

                                    [3] Enabled, 6.0 Gb/s

                00.0 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205909)

                00.1 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1215552)

                00.2 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205953)

                00.3 : NETAPP   X306_SMBPE02TSSM NA00 1695.4GB 512B/sect (ZC230K8T)

                00.4 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195992)

                00.5 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205958)

                00.6 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1211709)

                00.7 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195660)

                00.8 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205685)

                00.9 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205747)

                00.10: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205914)

                00.11: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1206677)

                00.12: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205692)

                00.13: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1210545)

                00.14: NETAPP   X306_SMBPE02TSSM NA00 1695.4GB 512B/sect (ZC230THW)

                00.15: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205578)

                00.16: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195610)

                00.17: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195699)

                00.18: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205711)

                00.19: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1215228)

                00.20: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1211553)

                00.21: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205999)

                00.22: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195969)

                00.23: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205976)

                10.0 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLB0LL)

                10.1 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVL0VEL)

                10.2 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLBBZL)

                10.3 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLBSGL)

                10.4 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZMGN)

                10.5 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZP8N)

                10.6 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLDN)

                10.7 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLLN)

                10.8 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLYP0N)

                10.9 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLWN)

                10.10: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZTHN)

                10.11: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLRN)

                10.12: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLKN)

                10.13: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLAN)

                10.14: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZMKN)

                10.15: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZWYN)

                10.16: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLTN)

                10.17: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLNN)

                10.18: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLGN)

                10.19: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZN4N)

                10.20: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZM7N)

                10.21: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVJNUPN)

                10.22: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZYMN)

                10.23: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZMLN)

                20.0 : NETAPP   X412_HVIPC560A15 NA03 560.0GB 520B/sect (Failed)

                20.1 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XJK23AP)

                20.2 : NETAPP   X412_S15K7560A15 NA04 560.0GB 520B/sect (6SL7E0610000N4172E7D)

                20.3 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XJX994P)

                20.4 : NETAPP   X412_HVIPC560A15 NA03 560.0GB 520B/sect (LXWUZT4L)

                20.5 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XK66KGR)

                20.6 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XK80W3P)

                20.7 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XK7V94P)

                20.8 : NETAPP   X412_S15K7560A15 NA04 560.0GB 520B/sect (6SL7JQNF0000N4200PBB)

                20.9 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XK6D9NR)

                20.10: NETAPP   X412_S15K7560A15 NA04 560.0GB 520B/sect (6SL7JGTV0000N4200QCF)

                20.11: NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XJKKZ5U)

                Shelf 0: DS4246E  Firmware rev. IOM6E A: 0142  IOM6E B: 0142

               Shelf 10: DS4243  Firmware rev. IOM3 A: 0172  IOM3 B: 0172

                Shelf 20: DS4243  Firmware rev. IOM3 A: 0172  IOM3 B: 0172

        slot 0: SAS Host Adapter 0b (PMC-Sierra PM8001 rev. C, SAS, <UP>)

                Firmware rev:       01.11.07.00

                Base WWN:           5:00a098:0035b51:34

                Phy State:          [4] Enabled, 3.0 Gb/s

                                    [5] Enabled, 3.0 Gb/s

                                    [6] Enabled, 3.0 Gb/s

                                    [7] Enabled, 3.0 Gb/s

                QSFP Vendor:        Molex Inc.     

                QSFP Part Number:   112-00177+A0   

                QSFP Type:          Passive Copper 2m ID:00

                QSFP Serial Number: 326722285

                00.0 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205909)

                00.1 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1215552)

                00.2 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205953)

                00.3 : NETAPP   X306_SMBPE02TSSM NA00 1695.4GB 512B/sect (ZC230K8T)

                00.4 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195992)

                00.5 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205958)

                00.6 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1211709)

                00.7 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195660)

                00.8 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205685)

                00.9 : NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205747)

                00.10: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205914)

                00.11: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1206677)

                00.12: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205692)

                00.13: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1210545)

                00.14: NETAPP   X306_SMBPE02TSSM NA00 1695.4GB 512B/sect (ZC230THW)

                00.15: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205578)

                00.16: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195610)

                00.17: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195699)

                00.18: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205711)

                00.19: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1215228)

                00.20: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1211553)

                00.21: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205999)

                00.22: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1195969)

                00.23: NETAPP   X306_WKOJN02TSSA NA01 1695.4GB 512B/sect (WD-WCC1P1205976)

                10.0 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLB0LL)

                10.1 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVL0VEL)

                10.2 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLBBZL)

                10.3 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLBSGL)

                10.4 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZMGN)

                10.5 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZP8N)

                10.6 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLDN)

                10.7 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLLN)

                10.8 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLYP0N)

                10.9 : NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLWN)

                10.10: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZTHN)

                10.11: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLRN)

                10.12: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLKN)

                10.13: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLAN)

                10.14: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZMKN)

                10.15: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZWYN)

                10.16: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLTN)

                10.17: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLNN)

                10.18: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZLGN)

                10.19: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZN4N)

                10.20: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZM7N)

                10.21: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVJNUPN)

                10.22: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZYMN)

                10.23: NETAPP   X412_HVIPC560A15 NA02 560.0GB 520B/sect (2AVLZMLN)

                20.0 : NETAPP   X412_HVIPC560A15 NA03 560.0GB 520B/sect (Failed)

                20.1 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XJK23AP)

                20.2 : NETAPP   X412_S15K7560A15 NA04 560.0GB 520B/sect (6SL7E0610000N4172E7D)

                20.3 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XJX994P)

                20.4 : NETAPP   X412_HVIPC560A15 NA03 560.0GB 520B/sect (LXWUZT4L)

                20.5 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XK66KGR)

                20.6 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XK80W3P)

                20.7 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XK7V94P)

                20.8 : NETAPP   X412_S15K7560A15 NA04 560.0GB 520B/sect (6SL7JQNF0000N4200PBB)

                20.9 : NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XK6D9NR)

                20.10: NETAPP   X412_S15K7560A15 NA04 560.0GB 520B/sect (6SL7JGTV0000N4200QCF)

                20.11: NETAPP   X412_HKCBF560A15 NA00 560.0GB 520B/sect (0XJKKZ5U)

                Shelf 0: DS4246E  Firmware rev. IOM6E A: 0142  IOM6E B: 0142

                Shelf 10: DS4243  Firmware rev. IOM3 A: 0172  IOM3 B: 0172

                Shelf 20: DS4243  Firmware rev. IOM3 A: 0172  IOM3 B: 0172

                        memory mapped I/O base 0xdf530000, size 0x10000

                        memory mapped I/O base 0xdf520000, size 0x10000

                        memory mapped I/O base 0x00000000df510000, size 0x10000

                        memory mapped I/O base 0x00000000df500000, size 0x10000

        slot 0: Intel USB EHCI Adapter u0a (0xdf101000)

                boot0   Micron Technology 0x655, class 0/0, rev 2.00/11.10, addr 2 1936MB 512B/sect (B8F0022700211791)

                        memory-mapped I/O base 0xdf101000, size 0x00000400

        slot 1: Dual 10 Gigabit Ethernet Controller IX1-SFP+

                e1a MAC Address:    00:a0:98:57:68:73 (auto-10g_sr-fd-up)

                    SFP Vendor:         FINISAR CORP.  

                    SFP Part Number:    FTLX8571D3BCL  

                    SFP Serial Number:  ARC0H8B        

                e1b MAC Address:    00:a0:98:57:68:74 (auto-10g_sr-fd-up)

                    SFP Vendor:         FINISAR CORP.  

                    SFP Part Number:    FTLX8571D3BCL  

                    SFP Serial Number:  ARC0H7T        

                Device Type:        82599, PBA 400900-000, FW Rev 0.3

                Serial Number:      9443537387

                Part Number:        111-00810

                Revision Number:    B0

                        memory mapped I/O base 0xdf600000, size 0x80000

                        I/O base 0x00000000ffffffe0, size 0x20

                        memory mapped I/O base 0xdf700000, size 0x4000

                        memory mapped I/O base 0xdf680000, size 0x80000

                        I/O base 0x00000000ffffffe0, size 0x20

                        memory mapped I/O base 0xdf704000, size 0x4000

ho-st02b> sysconfig -r

Aggregate aggr_SAS15K_600GB_B (online, raid_dp) (block checksums)

  Plex /aggr_SAS15K_600GB_B/plex0 (online, normal, active)

    RAID group /aggr_SAS15K_600GB_B/plex0/rg0 (normal, block checksums)

      RAID Disk Device          HA  SHELF BAY CHAN Pool Type  RPM  Used (MB/blks)    Phys (MB/blks)

      --------- ------          ------------- ---- ---- ---- ----- --------------    --------------

      dparity   0b.20.4         0b    20  4   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      parity    0b.20.9         0b    20  9   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.20.2         0b    20  2   SA:A   0   SAS 15000 560000/1146880000 560208/1147307688

      data      0a.10.23        0a    10  23  SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.20.5         0b    20  5   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.20.8         0b    20  8   SA:A   0   SAS 15000 560000/1146880000 560208/1147307688

      data      0b.20.1         0b    20  1   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.20.3         0b    20  3   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.20.6         0b    20  6   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.20.7         0b    20  7   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.20.10        0b    20  10  SA:A   0   SAS 15000 560000/1146880000 560208/1147307688

Aggregate aggr0 (online, raid4) (block checksums)

  Plex /aggr0/plex0 (online, normal, active)

    RAID group /aggr0/plex0/rg0 (normal, block checksums)

      RAID Disk Device          HA  SHELF BAY CHAN Pool Type  RPM  Used (MB/blks)    Phys (MB/blks)

      --------- ------          ------------- ---- ---- ---- ----- --------------    --------------

      parity    0a.00.2         0a    0   2   SA:B   0  BSAS  7200 1695466/3472315904 1695759/3472914816

      data      0a.00.4         0a    0   4   SA:B   0  BSAS  7200 1695466/3472315904 1695759/3472914816

Aggregate aggr_SAS15K_600GB_A (online, raid_dp) (block checksums)

  Plex /aggr_SAS15K_600GB_A/plex0 (online, normal, active)

    RAID group /aggr_SAS15K_600GB_A/plex0/rg0 (normal, block checksums)

      RAID Disk Device          HA  SHELF BAY CHAN Pool Type  RPM  Used (MB/blks)    Phys (MB/blks)

      --------- ------          ------------- ---- ---- ---- ----- --------------    --------------

      dparity   0a.10.1         0a    10  1   SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      parity    0a.10.11        0a    10  11  SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.13        0a    10  13  SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.15        0a    10  15  SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.17        0a    10  17  SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.19        0a    10  19  SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.21        0a    10  21  SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.3         0a    10  3   SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.5         0a    10  5   SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.7         0a    10  7   SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0a.10.9         0a    10  9   SA:B   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.0         0b    10  0   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.10        0b    10  10  SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.12        0b    10  12  SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.14        0b    10  14  SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.16        0b    10  16  SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.18        0b    10  18  SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.2         0b    10  2   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.20        0b    10  20  SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.22        0b    10  22  SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.4         0b    10  4   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.6         0b    10  6   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

      data      0b.10.8         0b    10  8   SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

Pool1 spare disks (empty)

Pool0 spare disks

RAID Disk       Device          HA  SHELF BAY CHAN Pool Type  RPM  Used (MB/blks)    Phys (MB/blks)

---------       ------          ------------- ---- ---- ---- ----- --------------    --------------

Spare disks for block checksum

spare           0b.20.11        0b    20  11  SA:A   0   SAS 15000 560000/1146880000 560879/1148681096

spare           0a.00.22        0a    0   22  SA:B   0  BSAS  7200 1695466/3472315904 1695759/3472914816

Partner disks

RAID Disk       Device          HA  SHELF BAY CHAN Pool Type  RPM  Used (MB/blks)    Phys (MB/blks)

---------       ------          ------------- ---- ---- ---- ----- --------------    --------------

partner         0a.00.14        0a    0   14  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.3         0a    0   3   SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.19        0a    0   19  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.21        0a    0   21  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.8         0a    0   8   SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.15        0a    0   15  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.9         0a    0   9   SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.12        0a    0   12  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.1         0a    0   1   SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.16        0a    0   16  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.6         0a    0   6   SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.7         0a    0   7   SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.17        0a    0   17  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.18        0a    0   18  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.0         0a    0   0   SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.13        0a    0   13  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.20        0a    0   20  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.11        0a    0   11  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.10        0a    0   10  SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.5         0a    0   5   SA:B   0  BSAS  7200 0/0               1695759/3472914816

partner         0a.00.23        0a    0   23  SA:B   0  BSAS  7200 0/0               1695759/3472914816

[amans]

Hi Shahbaz,

Thank you for the data, the disk on shelf 20, bay 0 has failed.

20.0 : NETAPP X412_HVIPC560A15 NA03 560.0GB 520B/sect (Failed)

Can you go ahead and replace this drive 20.0 and update

Regards,

Aman

[ShahbazRiaz]

The 20.0 is a new disk that was removed from free storage.

[ShahbazRiaz]

i used following command.

ho-st02b*> show disk 0b.20.0
show not found. Type '?' for a list of commands
ho-st02b*> show disk 20.0
show not found. Type '?' for a list of commands
ho-st02b*> disk unfail 20.0
disk unfail: Disk not found.
usage: disk unfail [-s (make disk spare)] <disk_name>
ho-st02b*>

ho-st02b*> disk show -n
disk show: No unassigned disks
ho-st02b*>

20.0 : NETAPP   X412_HVIPC560A15 NA03 560.0GB 520B/sect (Failed)

[GidonMarcus]

seems that you did

disk unfail 20.0

please try

disk unfail 0b.20.0

[ShahbazRiaz]

I tried comamnd "disk unfail 0b.20.0", but unfail command is not running because the disk is not assigned/associate with any controller.

As discussed with the client, he has resolved this issue using "disk zerospare/disk zeroing" etc.

Please clear for my information, is "disk zerospare" command affect the online aggregate/disk/volume?

is "disk zerospare" use for non-owner disk?

[amans]

Hello,

Disk zerospares command zeroes only non-zeroed spare  disks.

Regards,

Aman

[ShahbazRiaz]

Dear Aman,

can you share the difference in zero and non-zeroed? 

[amans]

Hi,

In simple words, non-zeroed means that data on the disk isn't erased and disk cannot be use for aggr expansion or creation but will be used for data reconstruction when disk fails.

On the other hand, once the disk is zeroed ( formats the disk by writing zeros ) and can be used aggr expansion/creation on data reconstruction .

Hope this clarifies!

Regards

Aman

[ShahbazRiaz · Accepted solution]

Thanks for detail and support

[amans]

You're welcome !

Have a great day !

Cheers,

Aman

[xiatian]

hi, 

  from the output of messages.   no fault disk is found.

  did you check the log messgaes ?   you need to  take a autosupport file . the open the compress file of  messages.logs.gz . you can see the lastest date  error's messages  about the disk.

00000026.000a46a0 3e56a862 Fri Jul 17 2020 22:22:00 +08:00 [cron_cron:info:19643] (operator) MAIL (mailed 188 bytes of output but got status 0x0001 )
00000026.000a46a3 3e56b4ea Fri Jul 17 2020 22:27:21 +08:00 [disk.ioMediumError:warning] Medium error on disk 0a.05.1: op 0x28:43f13400:0200 sector 1139881036 SCSI:medium error - Unrecovered read error - If the disk is in a RAID group, the subsystem will attempt to reconstruct unreadable data (3 11 0 81) (1535) [NETAPP X412_S15K7560A15 NA04] S/N [6SL72ZKC0000N40824C6]
00000026.000a46a5 3e56b832 Fri Jul 17 2020 22:28:45 +08:00 [raid.rg.diskcopy.done:notice] /aggr0/plex0/rg0: disk copy from 0a.05.1 to 0a.01.6 completed in 4:05:25.52
00000026.000a46a7 3e56b832 Fri Jul 17 2020 22:28:45 +08:00 [raid.config.spare.disk.failed:error] Spare Disk 0a.05.1 Shelf 5 Bay 1 [NETAPP X412_S15K7560A15 NA04] S/N [6SL72ZKC0000N40824C6] failed.
00000026.000a46a8 3e56b832 Fri Jul 17 2020 22:28:45 +08:00 [callhome.sdsk.fault:error] Call home for SPARE DISK FAILED

[xiatian]

hi, 

did you try the command "sysconfig -r"  , the output will include a item "broken disk". look like the following

Pool1 spare disks (empty)

Pool0 spare disks (empty)

Broken disks

RAID Disk Device HA SHELF BAY CHAN Pool Type RPM Used (MB/blks
) Phys (MB/blks)
--------- ------ ------------- ---- ---- ---- ----- -------------
- --------------
bad label 0a.00.4 0a 0 4 SA:A 0 SAS 15000 560000/114688
0000 560208/1147307688

before execute the command sysconfig -r , must be enter the advance mode

priv set advanced